Product ID:TT-V-121H, WATER RESISTING SPAR VARNISH
MSDS Date:04/19/1989
FSC:8010
NIIN:00-160-5852
MSDS Number: BJQMV

Emergency Phone: 201-333-6986

Info Phone: 201-333-6986

Cage: FO833

Telephone: 201-437-6501

Cage: 33150

MINERAL SPIRITS, EXEMPT

Fraction By Weight: 45%

OSHA PEL 500 PPM

ACGIH TLV: 125 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EYES: HIGH VAPOR CONC MAY BE IRRIT.
SKIN: SLIGHTLY IRRIT. PROLONGED/REPEATED EXPOSURE-DEFATTING, DRY
SKIN, LEADING TO IRRIT/DERMATITIS. INHALE: HIGH VAPOR CONC IRRIT TO
NOSE, RESPIRATORY TRACT. MAY CA USE CENTRAL NERVOUS SYSTEM
DEPRESSION. UNCONSCIOUSNESS/DEATH MAY OCCUR. INGEST: AVOID
ASPIRATION OF VOMITUS INTO LUNGS.
Effects of Overexposure:INHALATION: GIDDINESS, HEADACHE, DIZZINESS AND
NAUSEA. INGESTION: MAY RESULT IN VOMITING OR ASPIRATION PNEUMONITIS
WHICH MAY BE EVIDENCED BY COUGHING, LABORED BREATHING AND CYANOSIS
(BLUISH SKIN). IN SEVERE CASES, DEATH MAY OCCUR.
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN, AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT.

First Aid:EYES: FLUSH W/WATER-15 MINUTES WHILE HOLDING EYELIDS OPEN.
SKIN: FLUSH W/WATER. REMOVE CONTAM CLOTH & SHOES. WASH W/SOAP &
WATER. DO NOT REUSE CLOTH OR SHOES UNTIL CLEAN. INHALE: REMOVE TO
FRESH AIR. PROVIDE OXYGEN IF BREATHING DIFFICULT. GIVE CPR IF NOT
BREATHING. INGESTION: DO NOT INDUCE VOMIT. IF VOMIT OCCURS,KEEP
HEAD BELOW HIPS TO PREVENT ASPIRATION OF LIQUID INTO LUNGS. GET
NEEDED MED ATTN.

Flash Point Method:TCC
Flash Point:105F,41C
Lower Limits:1
Upper Limits:6
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM OR DRY
CHEMICAL.
Fire Fighting Procedures:DO NOT ENTER CONFINED SPACE W/O FULL GEAR &
SCBA. COOL FIRE EXPOSED CNTNRS W/WATER. DO NOT USE DIRECT STREAM
WATER ON POOL FIRES, WILL FLOAT/REIGNITE ON SURFACE
Unusual Fire/Explosion Hazard:COOL CONTAINERS EXPOSED TO INTENSE HEAT
FROM FIRES W/WATER TO PREVENT VAPOR PRESS BUILDUP,MAY RUPTURE. COOL
AREA W/LG AMTS WATER/PREVENT WEAKENING OF CONTAINER.

Spill Release Procedures:CAUTION!COMBUSTIBLE!ELIMINATE IGNITE
SOURCE.WEAR RSPRTR/PROTECT CLOTH.IF SAFE TO DO,SHUT OFF LEAK
SOURCE,DIKE,CONTAIN.REMOVE W/VACUUM TRUCKS/PUMP TO STORAGE/SALVAGE
VESS.SOAK UP W/ABSORB/PUT IN NON-LE AK CNTNRS/SEAL TIGHT.FLUSH AREA
W/WATER/DISPOSE.

Handling and Storage Precautions:KEEP LIQUID/VAPOR FROM IGNITE SOURCE.
MAY IGNITE W/O SPARK/FLAME. VAPOR MAY ACCUMULATE, TRAVEL TO IGNITE
SOURCE DISTANT FROM HANDLING SITE/FLASH-FIRE.
Other Precautions:KEEP CLOSED WHEN NOT IN USE. USE W/ADEQUATE VENT.
CONTAINERS, EVEN EMPTY, CONTAIN EXPLOS VAPORS. DO NOT CUT, DRILL,
GRIND, WELD, ETC. ON/NEAR CONTAINERS. STATIC ELEC MAY ACCUM &
CREATE FIRE HAZARD. GR OUND FIXED EQUIP & TRANSFER CONTAINERS.

Respiratory Protection:IF EXPOSURE MAY OR DOES EXCEED OCCUPATIONAL
EXPOSURE LIMITS, USE NIOSH-APPROVED RESPIRATOR AS REQUIRED TO
PREVENT OVEREXPOSURE. PER 29 CFR 1910, 134, USE EITHER
ATMOSPHERE-SUPPLYING RESPIRATOR OR AIR- PURIFYING RESPIRATOR FOR
ORGANIC VAPORS.
Ventilation:USE EXPLOSION-PROOF VENTILATION AS REQUIRED TO CONTROL
VAPOR CONCENTRATIONS WITHIN SUGGESTED PEL/TLV LIMITATIONS.
Protective Gloves:CHEMICAL-RESISTANT GLOVES.
Eye Protection:SAFETY GLASSES OR GOGGLES AS APPROPRIATE
Other Protective Equipment:SAFETY SHOWER, EYE BATH, AND WASHING
FACILITIES SHOULD BE AVAILABLE. USE OTHER CLOTHING AS REQUIRED TO
MINIMIZE COST.
Work Hygienic Practices:WASH W/SOAP & WATER BEFORE EATING, DRINKING,
SMOKING, USING TOILET FACILITIES. NO SMOKING WHERE MATERIAL IS
USED/STORED.
Supplemental Safety and Health
IF MORE THAN 2.0 ML PER KG INGESTED & VOMIT HAS NOT OCCURRED, INDUCE
EMESIS W/SUPERVISION. IF LOSS OF GAG REFLEX, CONVULSIONS,
UNCONSCIOUSNESS OCCUR BEFORE EMESIS, CONSIDER GASTRIC LAVAGE USING
CUFFED ENDOTRACHEAL TUBE. REPORT SPILLS INTO/LEADING TO WATER
SURFACE CAUSING "SHEEN" TO NAT'L RESPONSE CENTER. STORE/COOL.

HCC:F4
Boiling Pt:B.P. Text:323 TO 390F
Vapor Pres:0.1 PSI
Vapor Density:> AIR
Spec Gravity:.881
Evaporation Rate & Reference:SLOWER THAN ETHER

Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING AGENTS SUCH AS LIQUID CHLORINE, CONCENTRATED
OXYGEN, SODIUM OR CALCIUM HYPOCHLORITE.
Stability Condition to Avoid:AVOID HEAT AND FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE AND UNIDENTIFIED
ORGANIC COMPOUNDS DURING COMBUSTION.

Waste Disposal Methods:SEAL CONTAINERS, LABEL PROPERLY & DISPATCH TO
APPROVED WASTE DISPOSAL FACILITY. ASSURE COMPLIANCE W/LOCAL, STATE
& FED REGS. IF BECOMES WASTE MATERIAL, WOULD BE IGNITABLE HAZARDOUS
WASTE, #D001. REFER TO LATEST EPA OR STATE REGS FOR
PROPERDISPOSAL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.